Why is throttle free play important?
In simple words, throttle free play is a short bit of movement at the beginning of the throttle twist that has no effect. That free play allows you to bring the throttle open smoothly, and gently. … Throttle free play can make your bike more responsive and make it easier to ride smoothly.
How do you fix a loose throttle cable?
In order to fix a loose or tight throttle cable, you’ll need to turn this nut. Place the open ended wrench over the throttle body adjustment nut, and turn the nut either clockwise or counterclockwise until there is about 1/4 inch play in the tension of the throttle cable.
How can I make my throttle more responsive?
One of the easiest ways to improve engine and throttle response is by making sure your fuel filter is clean. When you stomp on the gas pedal, it sends a signal for more fuel to go into the engine.
Why is my bike losing power when I accelerate?
There are six main reasons why a motorcycle loses power when accelerating which are: Plugged jet in the carburetor. Broken carburetor spring. Vacuum leak on the carburetor or intake boot.
How tight should throttle cable be?
Most motorcycle manufacturers recommend about 2 to 3 millimeters of throttle free play, but over time the cables will stretch and settle into their housings and you’ll end up with more slack.
How do you fix a sticky throttle on a motorcycle?
When the motorcycle throttle sticks to acceleration mode, pull on the clutch, shift to neutral, and turn off the motorcycle. Do not turn on the motorcycle until the issue is resolved. If the throttle sticks to the closed position, turn off the motorcycle and inspect and clean the throttle and the throttle cable.
Why does my Harley have 2 throttle cables?
There are two cables because one of them is to open the throttle and one of them is to close the throttle in case the spring return doesn’t work. It’s a safety factor so get it fixed asap. The bike will be just fine with the main throttle cable,the other is,as posted above a safety cable.
Are throttle and idle cables the same?
Yes, the throttle(pull-open) cable is different from the idle(pull-close) cable. When measuring cables, measure the cable housing length. and be sure that you get the bend on the cable end that goes into the housing on the handlebars.
What can a loose throttle cable cause?
Symptoms of a Bad or Failing Throttle Control Cable
- Improper cable adjustment and slow acceleration response. When there is excess slack or the cable is too tight, this can cause intermittent delays in throttle response relative to pressing down on the accelerator pedal. …
- Dirty or frayed cable. …
- Cruise control not working properly.